Pianos routinely make movers yearly list of items that are most regularly harmed. Grand pianos are particularly problematic. Practicing the following treatments for taking apart, cushioning and filling grand pianos will avoid damage, lower claims cost, and enhance customer satisfaction.
1) A minimum of 3 people are required to manage an infant grand piano. If the child grand piano needs to go up or down stairs or if a complete or performance grand piano needs to be transferred, a minimum of 4 people are required.
2) Constantly complete a extensive and accurate inventory. It might be needed or preferable to use a visual inventory to properly explain and reveal pre-existing damage.
3) As various parts are taken apart, please location all hardware in an effectively labeled parts bag and after that put the parts bag in a "Components Box".
4) Remove the music rack (lyre) from its track by pulling it toward the keyboard. Wrap it in a tidy furnishings pad.
5) Disconnect the cover by getting rid of the hinge pins. Wrap the lid in a tidy furnishings pad.
6) Eliminate the prop that holds the lid open and cover it in a tidy furniture pad. The prop has a hinge pin and remains in 2 pieces.
7) Eliminate the pedal assembly and cover it in a tidy furniture pad. When eliminating the screws, please be mindful not to drop the braces. As you face the piano, number the push-rods from left to right as "1", "2", and "3", by putting a piece of masking tape with the proper number on each rod.
8) Pad the piano by positioning a clean rolled furniture pad (stretch-wrap the pad to prevent it from unrolling) on the cover of the keyboard to prevent it from flopping open while you handle the piano. Note: Please ensure that the surface area of the piano is dust-free before padding it.
9) Position a piano board and connect the straps so that it is prepared to receive the piano. The raised brace on the piano board ought to be at the keyboard end of the piano.
10) Remove the left front leg by positioning one individual underneath the piano at the left end of the keyboard. The other two individuals need to support the left front corner. The individual beneath the piano must turn the maintaining block so that the long end points far from the leg. The screws, if there are any, must then be gotten rid of. The "below" individual ought to then get out from under the piano prior to in fact getting rid of the leg. Be sure to have 2 people lifting the corner of the piano while the 3rd individual gets rid of the leg. Keep in mind: Please be sure to note which legs were gotten rid of from which positions since some pianos have check over here legs that are not interchangeable.
11) Place the piano on the piano board by decreasing the "leg-less" end onto the board. Please be sure to raise the whole piano somewhat while finishing this maneuver to prevent unnecessary pressure on the remaining, attached legs as the piano suggestions. Be sure that the piano is centered snugly versus the brace at the end of the piano board.
12) Get rid of the 2 staying legs and wrap them in clean furnishings pads. These legs are kept in place by a "key and slot" arrangement. To get rid of the leg, slide it inward towards the center of the piano up until it comes out of the slot.
13) Secure the piano to the piano board by bringing completions of the straps together and securing them. Place folded burlap pads over the furnishings pads however under the straps to provide additional protection to the edges of the piano. To avoid the strap near the narrow end of the piano from slipping off, connect the loose ends of the two straps together.
14) To move the piano over a flat, level surface, tilt the piano and piano board and location a four-wheel dolly under the center of the piano board.
15) To move the piano up or down stairs, utilize the piano board as a skid. After sufficiently padding the stairs for protection versus home damage, place the keyboard end of the piano towards the bottom of the stairs. Attach a bulge strap to the leading end of the piano board to prevent the piano from slipping.
16) To pack the piano, leave it on the piano board and place it in a tier as the very first base item with the keyboard dealing with the wall of the preceding tier. The best place to fill the padded cover is in between the piano and the preceding tier or in between the wall and the piano.
Although grand pianos represent a considerable obstacle, they can be moved without damage by utilizing typical sense and practicing the procedures listed above.